USSC 1851536CORN & PELLET MULTIFUEL STOVE6033OWNER’S MANUALInstallation - Operation - Maintenance Instructions - Repair PartsREAD THIS ENTIRE MANU
10 USSCALCOVE INSTALLATION REQUIREMENTSThe American Harvest is approved for the standard alcove height of 72 inches, or for a reduced alcove height w
USSC 11Locate proper position for the type “PL” wall thimble (F).Use a saber saw or keyhole saw to cut a 7 1/4-inch diameter hole through the wall (G
12 USSC6” Min.Non Combustible Hearth Plate6” Min.Fresh Air Intake(Optional) With 90Degree Elbow orHoodClean Out CoverTee3” Min.Wall ThimbleFlashingRai
USSC 1324” Min.FlashingRain CapStorm CollarWall ThimbleFresh Air Intake(Optional) With 90Degree Elbow orHoodClean Out CoverTeeWall Thimble6” Min.Non C
14 USSCYour American Harvest Corn/Pellet Stove comes to you with the glass door installed in place, ready for use. Theglass is surrounded on the edge
USSC 15STOVE CONTROLSSliding heat exchanger tubecleaner. Pull in and out to clean theheat exchanger tubesAdjustable Door Handlelifts up and turns left
16 USSCLIGHTING INSTRUCTIONSBefore lighting your American Harvest for the first time, make sure that allitems are out of the hopper and firebox area.
USSC 17CIRCUIT BOARD FUNCTIONSStart-upWhen the circuit board is energized (unit plugged in) there is a 15 second purging of the auger tube to allow fu
18 USSCSETTING THE DRAFTA proper draft setting is crucial to the successful burning of solid fuels. Draft refers to the amount of air flowing through
USSC 19Maintenance Instructions Continued...SPECIAL CLEANING/OPERATIONAL INSTRUCTIONS:After cleaning or when operating the unit you need to make sure
2 USSCSPECIFICATIONSUnited States Stove Company (manufacturer of the American Harvest Multifuel PelletStove) reserves the right to alter products, spe
20 USSCWARNINGThese automatic safety features must not be bypassedMicro SwitchThe hopper auger safety switch is mounted in the back of the hopper, up
USSC 21THERMOSTAT INSTALLATION•••••The American Harvest can be installed with and operated by a wall-mounted thermostat (Optional WT47) which maybe pu
22 USSCTROUBLE SHOOTINGUnplug stove before preforming any maintenance workPROBLEM CAUSES SOLUTIONS? Fire burns with a lazy, orange flameand/or fuel bu
USSC 23TROUBLE SHOOTING continued...PROBLEM CAUSES SOLUTIONS? Fire goes out or stove shuts downautomatically.•••••Hopper is empty.Fuel is not feeding.
24 USSCCAUTION: When performing any internal electrical maintenance• Moving parts inside of the cabinet may cause injury. Do not operate unit with
USSC 25WIRING DIAGRAM
26 USSCREPAIR PARTS DIAGRAM-603313451724252651524957414340395053545556384445373233343548303129474236262728121146710982322212016191513181458
USSC 27REPAIR PARTS LIST-6033KEY PART # DESCRIPTION QTY.1 25108B Pedestal Base, Painted 12 25171B Ash Pan Guide, Painted 13 25158B Pedestal Trim, Pain
28 USSCTHIS MANUAL WILL HELP YOU OBTAIN EFFICIENT, DEPEND-ABLE SERVICE FROM YOUR AMERICAN HARVEST, AND EN-ABLE YOU TO ORDER REPAIR PARTS CORRECTLY.KEE
USSC 3Ashes will have to be Removed from the stove periodically. See cleaning procedure. You can minimize cleaning requiredand maximize efficiency b
4 USSCSHELLED CORN (Dry, preferably corn with 11- 12% moisture content)•••••Corn must contain less than 14% moisture content. Wet corn will rapidly d
USSC 5FLOOR PROTECTIONThe American Harvest Multifuel Stove may be installed on a combustible floor, with proper floor protection, or on amasonry hear
6 USSCCLEARANCES TO COMBUSTIBLES continued...6”min.The side and top clearance are to be used wheninstalling in an Alcove as shown to the left andbelow
USSC 7GUIDELINES FOR EXHAUST VENTING SYSTEMS DESIGN continued...•••••••Distance from bottom of termination and grade-1ft./305mm minimum. This is cond
8 USSCFor installations with horizontal through-the-wall exhaust, it is strongly recommended that the stove combustion air beconnected to the outside.
USSC 9Note: Where passage through a wall, or partition of combustible construction is desired, the installationshall conform to CAN/CSA -B365The Amer
Commentaires sur ces manuels